Dahlgren Division, Naval Surface Warfare Center, 17320 Dahlgren Road, Dahlgren, VA 22448-5100

54 -- PURCHASE OF TWO (2) STORAGE TRAILERS SIZE 10' X 36' IAW SPECIFICATIONS SOL N00178-98-Q-0046 DUE 102898 POC R. C. Moss, Code SD18, 540-653-4304 or G. G. Scott, Code SD18, 540-653-4104 E-MAIL: Naval Surface Warfare Center, Dahlgren Division, mossrc@nswc.navy.mil. The Naval Surface Warfare Center, Dahlgren Division (NSWCDD), Dahlgren, Virginia, intends to purchase two (2) Storage Trailers, size 10 ft x 36 ft, to be delivered and installed on-site at NSWCDD. A complete list of specs follows: Size: 10 ft wide x 36 ft long (floor space) -- with detachable hitch; Floor: 360 sq. ft. bottom board -- roll type (class A), 324 sq. ft. Insulation (R11U (3-1/2 in.)), 360 sq. ft.; Floor Joists: 2 in. x 6 in. -- 16 in. on center, 360 sq. ft. Subfloor: single 5/8 in. plywood, 360 sq. ft. Floor finish: 1/8 in. vinyl tile; Exterior wall: 92 lf wall studs 2 in x 4 in x 8 ft, 16 in. on center Boca Framing, 92 lf top plate, single 2 in. x 4 in., bottom plate 2 in. x 4 in., 92 lf interior covering 5/32 in. paneling, 663 sf insulation: R11K (3-l/2 in.), 92 lf exterior siding: 5/8 in. Duratemp (T-111), 8 ft on center, painted, 92 lf exterior trim, wood, top, 92 lf exterior trim, wood, bottom, 4 ea exterior trim, wood, corner; Exterior- finish: color -- Richmond Bisque (54), Trim: Sandrift. (This is to match existing building exterior, Bldg. 1450). Roof: -- Load 30#, 36 lf 10 ft truss, Boca 80W, 16 in. on center, greater than 30#, 360 sf ceiling: 1/2 in. prefinished gypsum with rosettes, 324 sf insulation -- R19U (6 in.), 360 sf sheathing -- 7/16 in. OSB, 360 sf roofing -- 30 ga galvanized steel, 2 each attic vents -- gable end, gravity type, painted to match siding; Interior wall -- open floor (no interior partitions); no windows; Entry doors -- entry door 36 in. wide x 80 in. high lightweight steel with vinyl face and aluminum frame (lockable), with stay chain, drip cap, weatherstripping and lockset, lever type; Rollup door -- steel, coil-up, 8 ft., lockable. Trims -- 92 lf floor base, flat batten, prefinished, 4 each inside corner, flat batten, prefinished, 1 each outside corner, preformed molding, prefinished, 92 lf ceiling cove, flat batten, prefinished, 1 each ceiling -- 1-7/16 in. vinyl wrapped batten at seams, 1 each door jamb -- prefinished vinyl, wrapped type, 1 each door trim -- casing, prefinished; Electrical -- service 120/240V, single phase, 60 hertz, 100 amp w/main, single phase, Lights: 6 each diffused, surface mounted, 4 ft/2 tube fluorescent lights, w/2 each switches, toggle, 125V, 15 amp, 1 each exterior light to be mounted near entrance door, 9 each receptacles, duplex, 125V w/ground, 15 amp, 1 each 1-1/4 in. conduit from electrical panel through exterior wall for electrical input connection (no requirement for contractor to connect to main electrical source); HVAC -- 1 each central HVAC 2-ton cooling with 10 kw heat, 1 phase, 30 lf supply duct, ceiling, 8 x 16 fiberglass, 2 each diffusers -- 12 x 12 ceiling type w/damper, 1 each return air at unit; Plumbing -- None; Deck with steps -- 1 each OSHA approved 4 ft x 5 ft deck outside exterior entrance door, 1 set of steps attached to deck and extending to asphalt, No deck/steps required outside roll-up door on ends of trailers; Installation -- trailers to be placed on grass/dirt -- trailers will be located side by side as close as possible -- entrance doors facing out -- trailers will be set on cement blocks that are provided by the contractor -- contractor will anchor trailers and level -- contractor shall also install skirting around the entire bottom of both trailers -- contractor shall also remove and take with them upon leaving, all wheels, axles and hitches; Warranty -- 1 year manufacturer warranty on workmanship and materials; Quoters shall provide technical literature with their quotes which clearly demonstrates how the technical specifications have been met, inclusive of, but not limited to: pictures, model numbers and name of manufacturer. Award of this procurement will be made under Simplified Acquisition Procedures. There will be NO written solicitation issued as a result of this notice. However, a drawing of the installation concept and layout will be provided upon request by calling R. Moss, 540-653-4304 (or faxing your request to540-653-7016/540-653-6812/540-653-2958) and a copy of the drawing will be provided via return fax. A viewing of the site on which the trailers are to be installed shall be set for OCTOBER 14TH, 1998 AT 1:30PM. Directions to NSWCDD may be provided by calling R. Moss, 540-653-4304, or any one of the following technical representatives: Nalena Klaas, phone 540-653-3848, Gordon Carter, phone 540-653-5084, or Chris Lovejoy, phone 540-653-3849. Quoters visiting the site must be U. S. Citizens and must register in advance through the Main Gate Security Office, by calling 540-653-6890, Visitor Control, between the hours of 7:00 AM and 3:00 PM, Monday thru Friday. A map of NSWCDD will be furnished by Visitor Control to find the location of the site visit (Bldg 1450). Quoters are encouraged to arrive at the Main Gate early to avoid delays in getting to the site visit by 1:30 PM. Travel costs incurred for viewing the site in preparation for this quote is not the responsibility of the Government, nor will any prospective quoters be reimbursed any costs for such a site visit. SIC Code 2451 (500 employees) applies to this procurement. This procurement shall be set aside for small business. FAR 52.219-6 Notice of Small Business Set-Aside (Jul 1996) applies. Prospective quoters may fax their quotes to 540-653-7016, 540-653-6812 or 540-653-2958. POC for this procurement is R. Moss, 540-653-4304 for questions. E-mail address is: mossrc@nswc.navy.mil. The trailers shall be delivered F.O.B. Destination, to the Naval Surface Warfare Center, 17320 Dahlgren Road, Dahlgren, Virginia 22448-5100. Prospective quoters shall price each line item which appears herein: (1) Storage Trailer, 10 ft x 36 ft, 2 each; (2) Anchors for both trailers, 1 lot; (3) Skirting for both trailers, 1 lot; (4) OSHA steps/decking for both trailers, 1 lot; (5) Removal of wheels/axles/hitches from trailers and from site, 1 lot; (6) Blocking and leveling of both trailers, 1 lot. Closing date of this synopsis and submittal of bids shall be by close of business 28 October 1998, with anticipated award on or before 13 November 1998. Delivery of the two trailers shall be on or before 01 January 1999. Posted 09/28/98 (W-SN254994). (0271)

Loren Data Corp. http://www.ld.com (SYN# 0179 19980930\54-0001.SOL)