SOLICITATION NOTICE
J -- USCGC MANOWAR DRYDOCK REPAIRS FY14
- Notice Date
- 4/11/2014
- Notice Type
- Presolicitation
- NAICS
- 336611
— Ship Building and Repairing
- Contracting Office
- Department of Homeland Security, United States Coast Guard (USCG), USCG Surface Forces Logistics Center (SFLC) Procurement Branch 1, 300 East Main Street, Suite 600, Norfolk, Virginia, 23510-9102, United States
- ZIP Code
- 23510-9102
- Solicitation Number
- HSCG80-14-Q-P45E16
- Archive Date
- 11/28/2014
- Point of Contact
- Andrew J. Northcutt, Phone: 757-441-7032
- E-Mail Address
-
andrew.j.northcutt@uscg.mil
(andrew.j.northcutt@uscg.mil)
- Small Business Set-Aside
- Total Small Business
- Description
- The United States Coast Guard, Surface Forces Logistics Center, Detachment Norfolk VA, intends to issue a Commercial Request for Quotations (RFQ) for dry dock and repairs to the CGC MANOWAR (WPB-87330) an 87' Patrol Boat. The NAICS Code is 336611. The Coast Guard intends to conduct the procurement in accordance with Federal Acquisition Regulation (FAR) Part 12, Acquisition of Commercial Items, and FAR Part 13.5, Test Program for Certain Commercial Items. In accordance with FAR 52.232-18, the contract will be subject to the availability of appropriated funds. This acquisition will be issued as a 100% set aside for Small Business. The Request for Quotations (RFQ) will be issued on or about April 14, 2014. The acquisition is to perform dry dock and repairs to the CGC MANOWAR. The vessel is geographically restricted to a facility located within an area no greater than 750 nautical miles one-way and 1,500 nautical miles roundtrip from Galveston, TX. The Period of performance for CGC MANOWAR is sixty-five (65) calendar days from 20 August 2014 to 24 October 2014. All work will be performed at the contractor's facility within the geographical restriction as stated above. The solicitation will be issued electronically via the Federal Business Opportunity web page at http://www.fedbizopps.gov. It is incumbent upon contractors to monitor the FEDBIZOPS web page for the RFQ release and all subsequent amendments. Hard copies of the specification and solicitation will not be issued. The scope of the acquisition is for the overhauling, renewing and repairing of various items aboard the CGC MANOWAR. This work may include, but is not limited to: Ultrasonic Thickness Measurements, Perform (D) Ultrasonic Thickness Measurements, Perform (O) Dirty Oil Tank, Clean and Inspect (D) Oily Water Tank, Clean and Inspect (D) Tanks (MP Fuel Service), Clean and Inspect (D) Main Engine/Reduction Gear, Realign (O) Propulsion Shafts, Remove, Inspect, and Reinstall (D) Propulsion Shaft, Repair (O) Propulsion Shaft, Straighten (O) Intermediate Water-Lubricated Propulsion Shaft Bearing, Renew (O) Aft Water-Lubricated Propulsion Shaft Bearing, Renew (O) Intermediate Bearing Carrier, Renew (O) Aft Bearing Carrier, Renew (O) Stern Tubes, Interior Surfaces, Preserve 100% (O) Stern Tubes, Interior Surfaces, Repair (O) Propellers, Remove, Inspect, and Reinstall (D) Speed Log, Skin Valve Assembly, Clean and Inspect (D) Sea Water System (Sea Valves, Strainers, Piping), Clean, Inspect and Repair (D) Rudder Assemblies, Remove, Inspect and Reinstall (D) RHIB Notch Skid Pads, Inspect (D) RHIB Notch Skid Pad Studs, Renew (O) Stern Launch Door, Remove, Inspect and Reinstall (D) Grey Water Holding Tank, Clean and Inspect (D) Sewage Holding Tank, Clean and Inspect (D) Grey Water Piping, Clean and Flush (D) Sewage Piping, Clean and Flush (D) Hull Plating Freeboard, Preserve -"100%" (O) Main Mast, Preserve, 100% (O) Superstructure, Preserve "100%" (O) Superstructure, Preserve "Partial" (O) Cathodic Protection / Zinc Anodes, Renew (D) Drydocking (D) Temporary Services, Provide (D) Install Stainless Steel Hull Inserts and Renew BMDE Concentric Rings.(D) Decks - Exterior (Main Deck), Preserve (O) Depth Sounder, Capastic Fairing, Renew (O) U/W Body, Preserve (100%) (O) Hull Plating Freeboard, Preserve - Partial (O) If two companies are planning to conduct business as a Joint Venture or any other type of teaming agreement they shall provide past performance on projects of similar scope that they have performed together as a Joint Venture, if available. Providing individual past performance documentation from each company on separate projects where the two did not work together may be considered less relevant. A CD-ROM containing all applicable drawings will be sent via U.S. mail, if requested. Send all requests to Andrew.J.Northcutt@uscg.mil. The CD-ROM sets are available of all cutters and will be free of charge to contractors upon request. The CD-ROM(s) contain WINDOWS compliant raster/vector formats (e.g.*.DWF, etc). Quotations will be due on or about 12 MAY 2014 at 10:00 a.m. Eastern Standard Time and may be sent via: Email: Andrew.J.Northcutt@uscg.mil or mailed to US Coast Guard SFLC-CPD-C&P1-PBPL Attn: Andrew Northcutt 300 East Main Street, Suite 600 Norfolk, VA 23510-9102
- Web Link
-
FBO.gov Permalink
(https://www.fbo.gov/spg/DHS/USCG/COUSCGMLCA/HSCG80-14-Q-P45E16/listing.html)
- Place of Performance
- Address: At contractor's facitlity located within 750 nautical miles from Galveston, TX, United States
- Record
- SN03336926-W 20140413/140411235032-c6e3b1f51ef0ca24b61e2901dd09383b (fbodaily.com)
- Source
-
FedBizOpps Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |