SOURCES SOUGHT
45 -- Boiler replacement
- Notice Date
- 12/21/2012
- Notice Type
- Sources Sought
- NAICS
- 238220
— Plumbing, Heating, and Air-Conditioning Contractors
- Contracting Office
- Department of Labor, Employment Training Administration, Career Systems Development Corporation, 75 Thruway Park Drive Suite 100, West Henrietta, New York, 14586
- ZIP Code
- 14586
- Solicitation Number
- 1485
- Archive Date
- 1/16/2013
- Point of Contact
- Thayne Bodenmiller, Phone: 7165954211
- E-Mail Address
-
bodenmiller.thayne@jobcorps.org
(bodenmiller.thayne@jobcorps.org)
- Small Business Set-Aside
- N/A
- Description
- General Work Description: Demolish Boilers #1 and #2. Provide three new gas-fired low pressure hot water boilers and controls to replace the two old boilers. Proposal specifically includes: Demolish and legally dispose of the existing cast iron boilers. Modify the existing boiler flue as necessary. Furnish and install 3 new hot water boilers with at least 800 MBH output capacity, each. Boilers shall be at a minimum 92% CSA certified efficient with cast sectional heat exchangers and variable speed combustion air blowers with full modulation burners. Locate boilers on the existing concrete pads. Modify pads as necessary. Provide and install a new boiler plant control system designed for the boilers. Configure and modify existing 6" hydronic piping as necessary to accommodate the new boilers. Note - leave the existing 3-way control valves in place and remove actuation so valve can't modulate. Furnish and install 6" PVC combustion air piping and 8" CPVC exhaust air piping for each boiler. Cap off existing boiler breaching as necessary. Include roof penetration and patching. Furnish and install 3 new butterfly isolation valves, circuit setters and check valve. Provide and install 3 new low-water cut off units and 3 boiler relief valves. Boiler reliefs will be piped to floor drain. Install condensate coolers and piping as necessary Hydronic pipe insulation for new piping Boiler startup and 1 year full warranty for all new equipment. Boiler warranty after one year will be that which is provided by the equipment manufacturer. All Power and control wiring. Boiler Plant controls integration to the existing Schneider Electric-I/A web-based control network. One year full warranty. After year #1 boiler warranty will be that which is provided by the boiler manufacturer.
- Web Link
-
FBO.gov Permalink
(https://www.fbo.gov/spg/DOL/ETA/CSDC/1485/listing.html)
- Place of Performance
- Address: 8115 Glasgow Road, Cassadaga, New York, 14718, United States
- Zip Code: 14718
- Zip Code: 14718
- Record
- SN02955158-W 20121223/121221235428-56f23c95790760ea4e5ed7e1beb1c6b4 (fbodaily.com)
- Source
-
FedBizOpps Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |