SOURCES SOUGHT
99 -- DTFANM-12-R-00179- Refurbishment of the VORTAC facility in Pago Pago
- Notice Date
- 8/17/2012
- Notice Type
- Sources Sought
- Contracting Office
- FEDERAL AVIATION ADMINISTRATION, AAQ-530 AWP - Western Pacific
- ZIP Code
- 00000
- Solicitation Number
- DTFANM-12-R-00179
- Response Due
- 8/27/2012
- Archive Date
- 9/11/2012
- Point of Contact
- Lelanie Rivera, 425-227-1003
- E-Mail Address
-
lelanie.rivera@faa.gov
(lelanie.rivera@faa.gov)
- Small Business Set-Aside
- N/A
- Description
- RFO DTFANM-12-R-00119 IS NOW REPLACED WITH RFO DTFANM-12-R-00179 WHICH IS OPEN TO ALL BUSINESS FIRMS. OFFERS ARE DUE MONDAY, AUGUST 27, 2012 4PM PT. PLEASE SEE REVISED RFO ATTACHED. The purpose of this Request for offers is to seek competent and qualified contractors for the refurbishment of the Pago Pago VORTAC Facility at the Pago Pago International Airport. Summary of Work: This project scope describes the project requirements for refurbishing the Pago Pago VORTAC facility located at Pago Pago Intl Airport. The VORTAC building footprint is 37' X 37' on a concrete foundation with 10' cast in place concrete walls and a steel roof frame supporting a 53' diameter circular roof. The contractor shall furnish all management, labor, tools, equipment, transportation, and materials for the project. All work shall be accomplished by qualified experienced licensed contractors. See Section 1.04 for detailed specifications. Contractor shall submit a cost for each Contract Line Item Number (CLIN): CLIN 001: ROOF PREPARATION Remove TACAN, collar and teepee. Wrap and store TACAN. Dispose of old collar and teepee. Weatherproof all equipment and electronics inside the building. CLIN 002: DEMOLITION Remove existing roofing and insulation. Remove copper roofing. Remove existing wood decking and nailers connected to the steel joists. Remove fascia and soffits. Remove drop ceiling and light fixtures. Remove metal air conditioning (AC) rack from the front of the building. CLIN 003: ROOF REPLACEMENT Refurbish corroded steel fascia clips. Install trimmed wood nailers to the steel joists. Install 2X6 T&G wood decking. Install government furnished materials (GFM) antenna mount brackets. Install roof underlayment. Install 16 oz. copper sheeting. Install roofing insulation and fully adhered membrane roofing and associated flashing. Install 2X12 fascia and soffit. Install an attached gypsum wallboard ceiling. Install ladder supports. Install monitor antenna cable conduit and fittings. CLIN 004: TEEPEE INSTALLATION Assemble and paint GFM teepee. Assemble GFM collar and vent covers. Install teepee, collar and stored TACAN. CLIN 005: EXTERIOR WALL COATING Remove and dispose loose lead based paint (LBP) flakes. Concrete patch damaged wall areas. Paint the exterior walls and soffit with an epoxy undercoat and a polyurethane top coat. Paint is GFM. CLIN 006: ELECTRICAL Install interior suspended light fixtures and mounted exterior light fixtures. CLIN 007: BUILDING IMPROVEMENTS Paint two (2) existing exterior doors. Install a 3'X7' steel door and associated hardware to the transformer shed. Remove and replace a wall louver. Install a 12" concrete riser to a communication handhold. CLIN 008: TACAN MAST INSTALLATION Remove existing utility pole and messenger cable. Construct concrete foundation. Install buried duct from the VORTAC building to the foundation. Assemble and install GFM TACAN mast. CLIN 009: GROUNDING Install buried earth electrode system (EES) loop around the VORTAC building. Install ground rods and connect to the EES by exothermic welding. Connect the EES to the copper roof, building steel, transformer and main service entrance by exothermic welding. Install ground plates and connect to the EES. The applicable North American Industry Classification System (NAICS) code(s) are 236220 and 238160. Site Visit: The site visit is OPTIONAL, however the FAA urges and expects offerors to inspect the site where the work will be performed. A site walk will be conducted on July 18, 2012. Contractors are to meet the COR at 10:00 AM at the Pago Pago Int'l Airport terminal near baggage claim area. The COR will escort the Contractors to the VORTAC site. Contractor shall submit personnel information for the individual(s) that will represent the Contractor to the FAA representative 5 days prior to scheduled site visit. Contractor representative(s) shall be employees of the Contractor. The FAA representative is Jim Burress, phone number (808) 840-3728, cell (808) 721-6965 email: jim.burress@faa.gov. SUBMISSION OF OFFER: Offers are due by close of business (4pm, PST) on August 27th, 2012. Please see Section "L" of the attached Request for Offers package for complete proposal submission information. This Notice is for informational purposes for Minority, Women-Owned, and Disadvantaged Business Enterprises: The Department of Transportation (DOT), Office of Small and Disadvantaged Business Utilization, has programs to assist small businesses, small businesses owned and controlled by socially and economically disadvantaged individuals, and women-owned concerns to acquire capital and bonding assistance for transportation-related contracts. This is applicable to any eligible prime or subcontract at any tier. The DOT Bonding Assistance Program enables firms to apply for bid, payment, and performance bonds up to $1.0 million per contract. The DOT provides an 80 percent guaranty on the bond amount to a surety against losses. Loans are also available under the DOT short Term receivable financing. The maximum line of credit is $750,000. For further information regarding the bonding and lending programs please call the DOT Office of Small and Disadvantaged Business Utilization at (800) 532-1169. If you are viewing this announcement from another website, please be sure to view the original announcement at: http://faaco.faa.gov
- Web Link
-
FBO.gov Permalink
(https://www.fbo.gov/spg/DOT/FAA/WPR/DTFANM-12-R-00179/listing.html)
- Record
- SN02844748-W 20120819/120817235850-1a6e4d225c59809e768c039c0e2d0efa (fbodaily.com)
- Source
-
FedBizOpps Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |