AWARD
Y -- RECOVERY--Y--Repair Building P-10580 Motor Pool-Replace Roof and Repair Doors
- Notice Date
- 8/7/2009
- Notice Type
- Award Notice
- NAICS
- 236220
— Commercial and Institutional Building Construction
- Contracting Office
- Department of the Army, Army Contracting Agency, North Region, ACA, Fort Drum, ACA, Fort Drum, Directorate of Contracting, 45 West Street, Fort Drum, NY 13602-5220
- ZIP Code
- 13602-5220
- Solicitation Number
- EC-00505-9J
- Response Due
- 8/7/2009
- Archive Date
- 10/6/2009
- Point of Contact
- Barbara Hunt, 315-772-9050<br />
- E-Mail Address
-
ACA, Fort Drum
(barbara.hunt@us.army.mil)
- Small Business Set-Aside
- N/A
- Award Number
- W911S2-06-D-0005-0060
- Award Date
- 8/5/2009
- Awardee
- Chugach Industries Incorporated<BR>3800 Centerpoint Drive Suite 601<BR>Anchorage AK 99503
- Award Amount
- 2,541,209.14
- Line Number
- 3001
- Description
- This contract action was accomplished using other than competitive procedures because this is an order under an existing contract that was awarded using non-competitive procedures. RECOVERY: This firm fixed price task order number 60 was awarded under Contract W911S2-06-D-0005 to Chugach Industries Incorporated and funded by the American Recovery and Reinvestment Act (ARRA) of 2009. Rationale for this action is as follows: The existing contract is one of two contracts awarded under the authority of the SBA 8 (a) program for the repair, rehabilitation and construction services. The contract is one of the primary means of providing quick and responsive contract support to accomplish installation minor construction workload priorities and surges. To ensure the intent of the Recovery Act is met, this contract provides the most expeditious and efficient method of expending Recovery Act funds. Numerous subcontracting opportunities are associated with this contract. The work shall include all work in connection with the upgrade of Vehicle Maintenance Building P-10580 at Fort Drum, New York. Work shall include, but is not limited to, removing and replacing the overhead doors, including all exterior personnel doors. The interior doors and hardware shall be replaced with the same type as existing. The two sets of bathrooms shall be upgraded to include new toilets, urinals, sinks, mirrors, lighting, toilet partitions, urinal partitions, shower receptor and tile walls. The roof shall be replaced with EPDM gutter for the length of the building both sides and removal of EPDM roofing, insulation and OSB board and replaced with new insulation (same thickness and type as removed), 7/16 inch OSB over insulation, mechanically fastened with 0.060 EPDM roofing system fully adhered, snow load 70 PSF and 100MPH wind. The existing lube pits shall be upgraded by adding fiberglass grates (150 PSF rated), and lighting shall be upgraded to provide fluorescent units in the pit and the POL delivery system shall be upgraded. The floors in the repair bays shall be painted. The hand rails on the stairs and stairs themselves, to include steps, shall be painted. The acoustical ceiling shall be completely removed, to include the grid system and replaced with new tile. The floor tile shall be removed and replaced with new. Vinyl base shall be installed where tile is installed, and shall be stripped, sealed and waxed with one coat after installation. The electrical interior work shall include removing lights and replacing with new lights similar to the existing lighting fixture. In rooms 117, 118 and 119 Repair Bays, new 200 amp 3 phase panel will be installed for future use. The new panels shall be centrally located in the areas designated and shall be tied into main electric panels in the Room 116 electrical room. The exterior pavement around the building shall be milled down (asphalt only) 1.5 inches, tack coat placed and asphalt top placed 1.5 inches deep. New hose reels at existing locations in the repair bays will be installed to accommodate a water and compressed air reel for each bay. In the existing repair bays the contractor is to install a new vehicle exhaust reel (2 per bay) and fan similar to the ones installed in VMF P-10265, remove existing ductwork for exhausting vehicle exhaust and remove fans and seal outlets to the outside. There are approximately 28 reels and 14 exhaust fans. Two of the bays shall be designated a welding bay, and welding curtains and exhaust fans shall be installed similar to welding bay in VMF P-10265. The fire detection system shall be upgraded to current NFPA 70, NFPA 72, NFPA 101 and UFC-3-600-01 standards to include, smoke detectors, fire alarm panel, enunciator panel, pull stations, emergency lighting, audible signals, visual signals, exit lighting and mass notification system. A sprinkler system will be added to the building to include an FDC on the exterior of the building and standpipe on the main entrance for fire departments to connect into the building. This portion of the project will require 90% drawings for review and 100% stamped drawings prior to construction. The siding that has been damaged or lost shall be replaced with similar metal siding to match existing. Gates shall be replaced with three strands of barbed wire on top. In the entrance vestibules, where there is floor grating, contractor shall remove, clean pit and install new grates similar to existing. An oil water separator shall be installed outside the existing oil water separator room, or at another location designated by the Government. The type of oil water separator shall be manufactured by Rockford Sanitary Systems Incorporated. The new oil water separator shall have full and complete access from the surface and be sized properly to accommodate all water flow from the facility and integral storage with double wall construction, leak detection, a high level sensor and alarm.
- Web Link
-
FBO.gov Permalink
(https://www.fbo.gov/spg/USA/DABJ/DABJ17/EC-00505-9J/listing.html)
- Record
- SN01904354-W 20090809/090808001757-8dd201d6bc914e2593fef3abf577441a (fbodaily.com)
- Source
-
FedBizOpps Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |