SOLICITATION NOTICE
E -- Gasoline Storage Tank and set up of tank.
- Notice Date
- 3/31/2009
- Notice Type
- Presolicitation
- Contracting Office
- US Fish and Wildlife Service, MS 62680 17705 212th Ave NW Berthold ND 58718
- ZIP Code
- 58718
- Solicitation Number
- 62680-9-Q013
- Response Due
- 4/7/2009
- Archive Date
- 3/31/2010
- Point of Contact
- Darla Leslie, Upper Souris NWR Contracting Specialist 7014685467 darla_leslie@fws.gov;<br />
- Small Business Set-Aside
- Total Small Business
- Description
- U.S. Fish and Wildlife Service, Berthold, ND, has a requirement for a commercial item or service. This combined synopsis/solicitation is prepared in accordance with the format in FAR Subpart 12.603 (as supplemented with additional information included in this notice). This procurement is being issued as a 100% SMALL BUSINESS CONCERN SET-ASIDE IAW FAR 19.502-2(a). This posting will be referred to under Purchase Requisition Number: 626809Q013. This announcement constitutes the only solicitation. A written solicitation will not be issued. This RFQ falls under procedures in FAR Parts 12 and 13. This document incorporates provisions and clauses updated by way of the Federal Acquisition Circular (FAC) 2005-26, effective June 12, 2008. The North American Industrial Classification System (NAICS) number is 332420 Metal Tank (Heavy Gauge) Manufacturing with a business size standard of 500 employees. This requirement is advertised under full and open procedures. This announcement constitutes the Government's only official notice of this procurement. FWS' salient characteristics that will satisfy the Government's needs for its requirement for a gasoline storage tank and set up is: a) Vaulted Above Ground Storage Tank 1 EA b) Freight on Storage Tank 1 EA c) Remove and Dispose of old Tank 1 Job d) Replace Existing Concrete Slab 1 Job e) Placement of New Tank 1 Job TANK SPECIFICATIONS: **2000 gallon vaulted above ground storage tank for gasoline storage **Low profile rectangular design **Inner steel tank, lightweight fire resistive line, pressure testible outer steel jacket **Male NPT fittings, leak monitoring tube **Tank shall be painted beige/desert sand exterior epoxy finish **Tank must meed North Dakota Fire Specifications (see below) ND FIRE SPECIFICATIONS: **Tank must be constructed and listed with Underwriters Laboratories Inc, Standard 2085 for insulated Secondary Containment Aboveground tanks for Flammable and Combustible Liquids, protected type. 2 hour fire rating must exceed all requirements of the National Fire Protection Association Sections 30 and 30A for fire resistant tanks and meet the requirements of the Uniform Fire Code Articles 52 and 79, Appendix 11-F and Appendix A-11-F-1 for protected above ground tanks. **Tank shall be manufactured to withstand bullet penetration resistant according to Appendix 11-F of the Uniform Fire Code and vehicle impact resistant. **Tank shall have certification from CARB for Phase 1 and 2 Vapor Recovery. **Primary tank shall be fitted with: a 4 inch Fill Port, a 2 inch Normal Vent Port, 4 inch Emergency Vent Port, a 2 inch Liquid Gauging Port, a 2 inch Port for Dispensing Pump, a 4 inch Phase 1 Vapor Recovery Port and a 15 gallon Spill Containment with Lockable Lid and Drain Port to the primary tank. **Primary tank shall be pressure tested to UL 142 Standard (minimum3 to maximum 5 psi). **The primary steel tank shall be designed to store M85 (methanol), alcohol and petroleum blends. **The secondary tank shall be fitted with: a 2 inch annular space monitoring tube, a 2 inch normal vent port and a 4 inch emergency vent port, in addition to openings for all ports in the primary tank. **Port openings in the top of the secondary tank shall be constructed with full welds to prevent moisture from seeping between the fire proofing material and secondary and primary tanks. **The top of the secondary tank shall be sloped so that water will not accumulate on top of the tank. **The secondary tank shall have a 2 inch monitoring port including a tube which provides a means to detect product leakage from the primary tank into fire protection material that directly surrounds the primary tank. This design shall be listed under UL 2085. **Tank shall be fitted with either an Internal or external fire valve installed. (North Dakota Fire Marshal requirement) **Tank filling will have a provision to sound an audible alarm at 90% tank capacity and a provision to automatically stop liquid flow at 98% tank capacity installed. (North Dakota Fire Marshal requirement) ***************************************************************************************************************************************** INFORMATION ABOUT EXISTING TANK THAT MUST BE REMOVED AND DISPOSED OF: **2000 gallon rectangular tank with an estimated weight of 20,000 lbs **Tank was used for unleaded gasoline storage ***************************************************************************************************************************************** INFORMATION ABOUT EXISTING CONCRETE SLAB THAT MUST BE REPLACED: **Remove and dispose of existing slab (approximately 12' x 8' x 10" thick) **Remove existing fill dirt (mostly sand) **Pack with clay to support the quoted tank and 2000 gallons of unleaded fuel. The Refuge can supply the clay and any gravel needed. SPECIFICATIONS FOR NEW CONCRETE SLAB: **Bearing Capacity: 2,000 lb. per sq. ft. **Total settlement: 1 inch maximum **Differential settlement: 1/2 in. maximum **Provide a minimum 6 inch (6") thick granular sub-grade, compacted and graded to a level uniform subsurface prior to the cast slab placement or pouring of the cast-in-place slab. **Finished slab shall be 13' x 8.5' x 12" thick, reinforced 1 piece slab, broom finished. Delivery AddressU.S. Fish and Wildlife ServiceUpper Souris NWR17705 212th Ave NWBerthold, ND 58718 Please submit your quote on company letterhead with all pertinent point of contact information including CCR Cage Code, DUNS No., Tax Id No., and business size/type. In addition, your quote should provide unit price, total price, delivery date, and FOB Destination. No formal format is required as this is a combined synopsis/request for quote solicitation. If your company has a GSA contract, please provide the GSA Contract No. as well. Offers must be received NLT close of business, 7 April 2009, at U.S. Fish and Wildlife Service, Upper Souris NWR, 17705 212th Ave NW, Berthold, ND 58718. Offers received after this date and time will be considered non responsible in accordance with 52.212-1(f) and will not be evaluated. Quotes may be emailed or faxed to the attention of Darla Leslie, Contract Specialist, (701)468-5467, (701) 468-5600 (fax), or email to darla_leslie@fws.gov. Offeror must comply with all instructions contained in FAR 52.212-1, Instructions to Offerors - Commercial Items. The provisions at 52.212-2, Evaluation - Commercial Items, applies to this acquisition. Evaluation factors are price and delivery. Offers shall include a completed copy of the provision at 52.212-3, Offeror Representations and Certifications - Commercial Items, with its offer. The clause 52.212-4, Contract Terms and Conditions - Commercial Items, applies to this acquisition. Also included in this acquisition are the following clauses: 52.204-7, 52.215-5, 52.219-06, 52.222-50, 52.225-01, 52.232-1, 52.233-1, 52.243-1, 52.246-20, 52.252-5, 52.252-6, FWS 1452.204-1, 1452.212-1, and1452.242-7. The clause at 52.212-5, Contract Terms and Conditions Required to Implement Statutes or Executive Orders - Commercial Items applies to this acquisition, no addenda applies. Additional FAR clauses cited in this clause applicable to this acquisition are: 52.219-28, 52.222-3, 52.222-19, 52.222-21, 52.222-26, 52.222-36, 52.225-13, 52.232-33, 52.233-3, 52.233-4, 52.237-11. The full text of any solicitation provision or clauses referenced herein may be accessed electronically at http://farsite.hill.af.mil.
- Web Link
-
FedBizOpps Complete View
(https://www.fbo.gov/?s=opportunity&mode=form&id=fb55105970f19ffbb03a02f73de66f05&tab=core&_cview=1)
- Place of Performance
- Address: Upper Souris National Wildlife Refuge17705 212th Ave NWBerthold, ND 58718<br />
- Zip Code: 587189666<br />
- Zip Code: 587189666<br />
- Record
- SN01782214-W 20090402/090331222158-fb55105970f19ffbb03a02f73de66f05 (fbodaily.com)
- Source
-
FedBizOpps Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |