Loren Data's SAM Daily™

fbodaily.com
Home Today's SAM Search Archives Numbered Notes CBD Archives Subscribe
FBO DAILY ISSUE OF SEPTEMBER 23, 2007 FBO #2127
SOLICITATION NOTICE

23 -- Tyndall AFB Weapons of Mass Destruction (WMD) Hazmat Trailer

Notice Date
9/21/2007
 
Notice Type
Solicitation Notice
 
NAICS
336212 — Truck Trailer Manufacturing
 
Contracting Office
Department of the Air Force, Air Education and Training Command, Tyndall AFB Contracting Squadron, 501 Illinois Ave, Ste 5 Bldg 647, Tyndall AFB, FL, 32403-5526, UNITED STATES
 
ZIP Code
32403-5526
 
Solicitation Number
Reference-Number-F4A3617227AG01
 
Response Due
9/25/2007
 
Archive Date
10/10/2007
 
Point of Contact
Gene Randall, Contract Specialist, Phone 850-283-8649, - Jenifer Lash, Contracting Officer, Phone 850-283-8617, Fax 850-283-3963,
 
E-Mail Address
gene.randall@tyndall.af.mil, jenifer.lash@tyndall.af.mil
 
Small Business Set-Aside
Total Small Business
 
Description
This is a combined synopsis and solicitation for Tyndall AFB for the following commercial item: Quantity of one Weapons of Mass Destruction (WMD) Hazmat Trailer. Salient Characteristics are as follows: (Note that all part numbers are based on Wells Cargo product numbers. These are for informational purposes and we will accept ?or equal? items constituting the entire package that meets the same requirements) 1 Ea 30' Express Wagon Wide Body. 1 Ea Base Model - EW3039W - 98 1/4" Body Width. 6 Ea Welded Heavy Duty Forged Lashing Ring- Install 1 set at rear corner, 1 set just forward of wheel boxes and 1 set at front corners. Military Hurricane, Air, Sea Trailer tie down system. 1 Pr Heavy Duty Rear Cornerpost Jacks - 3000lb Static Load Capacity. 1 Ea Three Piece 'A' Frame Included. 1 Ea 2 1/2" Adjustable Height Pintle Eye Coupler (20000lb GVWR). 2 Ea D.O.T. Compliant 1/2" Safety Chain with Clevis Safety Slip Hook and Latch. 1 Ea 8" x 3" Rectangular Steel Tube Mainrails with Equal Height 'C' Section Crossmembers with Square Outriggers & Steel Side Plates. 3 Ea 6000lb, 102"W, 10 Degree Up Torflex Axle with 12" x 2" Electric Brakes, E/Z Lube, and 8 on 6.5 Hubs and Drums with Weather Resistant Wiring Package. 6 Ea ST235/80R16 Load Range 'D' Radial Tire Mounted on an 8 Bolt Electro Deposition Coated Silver Spoke Wheel. 1 Ea Chassis Fully Undercoated with CPC (Corrosion Preventative Compound). 30 LF 8'0" Inside Height, 90 3/4" Vertical Posts Located on 16" Centers. 1 Ea Generator Compartment with Fuel Door. 1 Ea 30"W Single Side Entry Door, Aluminum RH Hinge with Flush Lock- START 68" OFF FRONT INSIDE WALL ON CURBSIDE. Door Opening: 30"W x 80"H. 1 Ea 30"W Single Side Entry Door, Aluminum RH Hinge with Flush Lock- INSTALL ON CURBSIDE WALL STARTING AT FRONT OF WHEEL BOX. Door Opening: 30"W x 80"H. 1 Ea 30"W Single Side Entry Door, Aluminum RH Hinge with Wells Cargo Flush. Lock- INSTALL ON CURBSIDE WALL STARTING 12" OFF REAR OF WHEEL BOX. Door Opening: 30"W x 80"H 1 Ea Swing Down Rear Ramp Door with Spring Assist and Aluminum Anti-Rack Cam Bar Lock. Door Opening: 90 3/4"W x 87"H. 1 Ea 85 1/8" Wide x 12 1/2" Long Extruded Aluminum Ramp Extension ? 2400 lb. Capacity 3 Ea 30" x 15" Radius Tinted Glass Horizontal Slider Window- - CENTER 1 EA. FRONT WALL - INSTALL ON ROADSIDE WALL CENTERED OVER GENERATOR HOUSING - INSTALL 1 EA. ON CURBSIDE START 9" FORWARD OF FRONT CURBSIDE DOOR 1 Ea 24 FT. LONG ROLL UP AWNING WITH CENTER SUPPORT ARM COLOR: (EH) PEWTER 30 LF 3/4" Exterior Grade Plywood Floor, Exterior Surface Undercoated, Interior Surface Painted Gray 30 LF Seamless Non-Skid Vinyl Floor Covering, Color: Black, Pattern: Raised Circles- INSTALL IN FRONT 10 FT. SECTION 30 LF 1/4" White Kemlite Plywood Interior Sidewall Liner 30 Ea 1 5/8" Fiberglass Sidewall Insulation, R5 Value 1 Ea INSULATE PARTITION WALL 30 LF Full Width Ceiling Lined with White Kemlite Covered 1/4" Plywood Contoured to Roof Radius (Includes Lining End Caps) 1 LF Full Width Flat Ceiling Lined with White Kemlite Covered 1/4" Lauan Plywood 30 LF 1 5/8" Ceiling Insulation 1 Ea Full Width Partition Wall without Door- START 10 FT OFF FRONT INTERIOR WALL 8 Ea 18"High x 18"Deep x 95"Long Overhead Cabinet --INSTALL ON FRONT SIDE OF PARTITION WALL AS HIGH AS POSSIBLE. EQUALLY SPACE SWING OUT DOORS WITH POSITIVE LOCKS. LAMINATE COLOR TO BE WHITE. 1 Ea LINE BOTH SIDES OF PARTITION WALL WITH 1/4" KEMLIGHT COVERED PLYWOOD. 6 Ft 24" HIGH x 24" DEEP x 66" LONG OVERHEAD CABINET WITH EQUALLY SIZED DOORS EQUIPPED WITH POSITIVE LOCKS.- INSTALL ON FRONT WALL STARTING AT FRONT CURBSIDE CORNER. LAMINATE COLOR TO BE WHITE. 3 Ft 33"H x 28"D x 36'L Base Cabinet with Laminated Front & Top, One Shelf and Positive Latches on Doors- INSTALL BETWEEN REAR OF GENERATOR HOUSING AND PARTITION. NOTE: DO NOT INSTALL INTERIOR SHELF. THE BREAKER BOX WILL BE LOCATED INSIDE THIS CABINET. SIZE DOOR FOR EASY ACCESS TO BREAKER BOX. 12 SFT Laminated Permanent Inside Counter - 66" LONG x 24" DEEP - COLOR TO BE LIGHT GREY - INSTALL ON FRONT WALL STARTING AT CURBSIDE CORNER. SET COUNTER HIGHT AT 28". 1 Ea Hard Wire Generator Directly into Service Panel (Service Panel Should be Located Within 4Ft of Generator) 1 Ea 100 Amp, 120V/240 Volt 16 Circuit Service Panel with 100 Amp Main Breaker-- INSTALL ON ROADSIDE WALL INSIDE BASE CABINET 12 Ea 15 Amp, 120 Volt Duplex Wall Receptacle: - EQUALLY SPACE 4 EA. ACROSS REAR SIDE OF PARTITION WALL. SET AT 12" OFF FLOOR. - CENTER (2 EA.) ACROSS FRONT SIDE OF PARTITION WALL BEWTEEN BASE CABINET AND ON ROADSIDE AND CURBSIDE WALL.. SET AT 12" OFF FLOOR. - CENTER (2 EA) ABOVE COUNTER ON ROADSIDE WALL, 6" FROM COUNTER SURFACE. - CENTER (2 EA.) ABOVE COUNTER ON ROADSIDE WALL, 6" FROM COUNTER SURFACE. - CENTER (2EA) BETWEEN REAR OF SIDE DOOR AND PARTITION WALL, 12" OFF FLOOR 1 Ea Exterior 15 Amp, 120 Volt GFI Duplex Receptacle (Weather Proof) Surface Mounted- CENTER ON CURBSIDE WALL BETWEEN REAR OF WHEEL BOX AND REAR CORNER. RECESS INTO EXTRUSION. 6 Ea Interior Wall Switch for 120 Volt Electric- - INSTALL 1 EA AT REAR OF FRONT SIDE DOOR TO CONTROL FRONT AREA CEILNG LIGHTS - INSTALL 1 EA AT FRONT SIDE DOOR TO CONTROL ROADSIDE EXTERIOR RECESSED LIGHTS - INSTALL 1 EA AT FRONT SIDE DOOR TO CONTROL CURBSIDE EXTERIOR RECESSED LIGHTS - INSTALL 1 EA AT FRONT SIDE DOOR TO CONTROL FRONT WALL EXTERIOR TELESCOPING LIGHTS - INSTALL 1 EA AT FRONT SIDE DOOR TO CONTROL SIDEWALL AT REAR CORNERS EXTERIOR TELESCOPING LIGHTS - INSTALL 1 EA AT REAR ROADSIDE CORNER TO CONTROL REAR COMPARTMENT CEILING LIGHTS 5 Ea 4Ft Double Fluorescent Light Fixture with Diffuser Cover (Tubes Not Included)- CENTER 1 EA. TO UNDERSIDE OF FRONT WALL OVERHEAD CABINET. - CENTER 1 EA. BETWEEN A/C AND FRONT WALL CABINET - CENTER 3 EA. EQUALLY SPACED IN REAR AREA CEILING 4 Ea Exterior 120 Volt, 500 Watt Telescoping Removable Quartz Light (Includes GFI Outlet & Mounting Bracket)- INSTALL 1 EA. PER CORNER ON FRONT WALL. - INSTALL 1 EA PER CORNER ON EACH SIDEWALL AT REAR CORNERS. PLACE LIGHTS AS HIGH AS POSSIBLE AND STILL BE REACHABLE FROM THE GROUND BY A 6 FT. TALL PERSON. 4 Ea 500 Watt Recessed Quartz Flood Lights- - INSTALL 1 EA ON ROADSIDE AND CURBSIDE WALL BETWEEN 1ST & 2ND VERTICAL POST OFF REAR CORNEPROST - INSTALL 1 EA. ON ROADSIDE AND CURBSIDE WALL AS NEAR FRONT CORNERPOST AS POSSIBLE. SET TOP OF EACH RECESSED LIGHT LEVEL WITH TOP OF SIDE DOOR 3 Ea 120 Volt, 13500 BTU ** Low Profile ** Roof Mounted Air Conditioner with 5600 BTU Heat Strip- - CENTER 1 EA 5 FT. OFF FRONT WALL - CENTER 1 EA 6 FT. OFF REAR DOOR - CENTER 1 EA. 11' 6" OFF REAR DOOR 30 LF .030 Prefinished Victory Red Smooth Exterior Aluminum Installed Vertically BONDED to Vertical Posts 30 LF **** Exterior Aluminum BONDED to Vertical Posts **** 1 Ea 24" High Aluminum Tread Plate Stone Guard with Wrapped Integrated Corners 30 Lf D.O.T. Required Conspicuity Tape Installed on Both Sides and Rear of 0.00 0.00 Trailer 2 Ea L.E.D. Wraparound Tail Light with Integrated Side Rear Marker Light 1 Ea Wells Cargo L.E.D. Safety Package - Consists of L.E.D. Clearance Lights in Place of Standard Clearance Lights. Clearance Lights on Rear Roof Cap used as High Profile Brake Light and Side Mounted Clearance Lights used as Turn Indicators. 1 Ea S.A.E. Color Coded 12 Volt Electrical System, D.O.T. Required Exterior Lighting Package 1 Ea D.O.T. 'A' Frame Mounted 22 Amp Hour UI Series Battery, Breakaway Switch, Aluminum Mounting Bracket, Cover, Battery "Charge" Indicator,and Diode Isolation. Battery Acid Included 1 Ea Seven Way Trailer End Connector 10 LF Fold Down Guard Rail for Roof Top Platform 1 Ea Permanent Aluminum Ladder- CENTER ON FRONT WALL 1 Ea 10 Ft Long Aluminum Roof Platform with 3/4" Wolmanized Plywood -START AT FRONT OF THE TRAILER AND BUILD TOWARD REAR 1 Ea 12.0KW Onan Commercial Quiet Diesel Generator Package - 110 Volt with 25Ft Remote Harness - 2 Year Warranty*** Includes Steel Lined Generator Compartment, Remote Start with Hour Meter, Above Floor Fuel Compartment with Access Door, 22 Gallon Steel Fuel Tank, Fuel Guage, Exterior Generator Door, 100 Amp Deep Cycle Battery Mounted Inside Compartment and Charging System- INSTALL ON ROADSIDE WALL STARTING AT FRONT CORNER 1 Ea CUSTOM GRAPHICS PACKAGE This synopsis and solicitation is prepared in accordance with the format in FAR Subpart 12.6 as supplemented with additional information included in this notice. This announcement constitutes the only solicitation; quotes are being requested and a written solicitation will not be issued. This solicitation is issued as a request for quote (RFQ). North American Industrial Classification System (NAICS) code 336212 applies to this procurement. The small business size standard is: 500 employees. This procurement is being issued as 100% SMALL BUSINESS SET-ASIDE. This solicitation document and incorporated provisions and clauses are those in effect through Federal Acquisition Circular 2005-18 and Defense Change Notice 20070802. FOB: Destination for delivery to 325 CES/CEF, 1129 Florida Ave (Stop 42), Tyndall AFB, FL 32403. < NOTE: THIS NOTICE WAS NOT POSTED TO FEDBIZOPPS ON THE DATE INDICATED IN THE NOTICE ITSELF (21-SEP-2007); HOWEVER, IT DID APPEAR IN THE FEDBIZOPPS FTP FEED ON THIS DATE. PLEASE CONTACT fbo.support@gsa.gov REGARDING THIS ISSUE.
 
Web Link
Link to FedBizOpps document.
(http://www.fbo.gov/spg/USAF/AETC/TynAFBCS/Reference-Number-F4A3617227AG01/listing.html)
 
Place of Performance
Address: Tyndall AFB, Florida
Zip Code: 32403
Country: UNITED STATES
 
Record
SN01414197-F 20070923/070921223649 (fbodaily.com)
 
Source
FedBizOpps Link to This Notice
(may not be valid after Archive Date)

FSG Index  |  This Issue's Index  |  Today's FBO Daily Index Page |
ECGrid: EDI VAN Interconnect ECGridOS: EDI Web Services Interconnect API Government Data Publications CBDDisk Subscribers
 Privacy Policy  Jenny in Wanderland!  © 1994-2024, Loren Data Corp.