SOURCES SOUGHT
66 -- QUARTZ LABWARE
- Notice Date
- 6/25/2004
- Notice Type
- Sources Sought
- Contracting Office
- ESC/PKOP, Services Branch, 20 Schilling Circle, Bldg. 1305, 3rd. floor, Hanscom AFB, MA 01731-2800
- ZIP Code
- 01731-2800
- Solicitation Number
- FUGPL941450200
- Response Due
- 6/29/2004
- Archive Date
- 7/30/2004
- Point of Contact
- Kathleen M. Brock, Contracting Specialist 781-377-1352
- E-Mail Address
-
Email your questions to Click Here to E-mail the POC
(kathleen.brock@hanscom.af.mil)
- Small Business Set-Aside
- Total Small Business
- Description
- NA This is a combined synopsis/solicitation for commercial items prepared in accordance with the format in FAR Subpart 12.6, as supplemented with additional information included in this notice. This announcement constitutes the only solicitation; proposals are being requested and a written solicitation will not be issued. This requirement is set-aside for small business only. The NAICS Code for this synopsis/solicitation is 327212, Size Standard 750. Solicitation/Purchase Request number FUGPL941450200 is issued as a Request for Quote (RFQ). This document incorporates provisions and clauses that are in effect through Federal Acquisition Circular 2001-24 effective 18 June 2004. The Government intends to award one contract line item number (CLIN 0001) for Glass Fabrication of: 1. 37 x 40 mm x 5 foot, plus 42+ x 45 mm x 1 foot quartz reactor closed small end (flat as possible), with two hooks at 180 degrees 1" from large open end. Large end will have ID o-ring seal. Qty. 1 2. 42 x 45 mm x 30" qtz liner dump tube, F/P ends Qty. 8 3. 50 x 55 mm x 33" Quartz furnace tube, #50 o-ring, sealed disk other end w/ ? inch od port thru disc (off-center) Qty. 1 4. 6.35 mm (1/4 inch precision) quartz tubing, 4 feet each Qty. 16 5. 21 mm OD x 12 cm long quartz boat, full end with handle, 15 mm high 10 cm open length (HVPE) Qty. 6 6. Wafer Sled (HVPE) Qty. 2 7. 25.4 mm (1 inch precision) x 20" long Quartz injector tube (HVPE) open both ends Qty. 4 8. 66 x 70 mm x 35" Quartz Dump Tube (HVPE) Qty. 12 9. 75 x 80 mm x 38" + 110 mm x ? inch flanges quartz furnace tube HVPE AlN Qty. 1 10. 75 x 80 mm x 48" + 110 mm x ? inch flanges quartz furnace tube HVPE GaAs Qty. 1 11. 42 x 45 mm x 33.5" long droop tube iodine reactor with 34/45 mm female ground glass joint Qty. 2 12. 42 x 45 mm x 33.5" long droop tube iodine reactor with 34/45 mm female ground glass joint and 10 x 12 mm narrow middle section Qty. 2 13. 48 x 54 mm x 56" Quartz furnace tube, #50 o-ring one end, with twin ? inch od elboe tubulations other end Qty. 2 14. Repair internal and external quartz tubulations on iodine reactor (#11 and #12) Qty. 2 15. Quartz Synthesis Ampoule 50 x 54 mm x 18 cm Qty. 8 16. Quartz Growth Ampoule 60 x 64 mm x 21 cm with seed necking Qty. 8 17. Quartz "Cap" for Heater Housing 11 x 13 mm x 24 cm with 50-52 mm fluting Qty. 8 18. Quartz Submerged Heater Housing 5 x 7 mm x 16 cm w/ 46 x 50 mm x 4 cm housing Qty. 8 Note: Items 2, 4 and 8 are straight plain tubes, open both ends and fire polished Also: all items fire polished finish for any cut edges or machined surfaces Also: Material used for fabrication will be GE 214 quartz or better grade, unless specified by the Point of Contact, George Bryant, 781-377-4806 and Offerors must be located within 15 miles of Bedford, Massachusetts. Transportation of the material to be repaired and pick up of items will be the responsibility of the Air Force Research Laboratory POC. QUANTITY: note CLIN 0001 above. UNIT OF MEASURE: ea. DESIRED DELIVERY DATE: June 30, 2004 through May 31, 2005. FOB: DESTINATION. Inspection and acceptance: DESTINATION. The following provisions and clauses apply to this procurement: FAR 52.212-1, Instructions to Offerors-Commercial Items; In accordance with the FAR 13.106-1(a)(2) offerors are notified that award will be made on the basis of price. Offeror will be evaluated in accordance with FAR 13.106-2 FAR 52.212-4 Contract Terms and Conditions-Commercial Items; FAR 52.212-5 Contract Terms and Conditions Required to Implement Statutes or Executive Orders-Commercial Items. [in paragraphs (b) and (c) the following clauses apply 52.219-6; 52.222-3; 52.222-19; 52.222-21, 52.222-26, 52-222-36, 52.225-13, 52.232-33; 52.222-48; Addendum to FAR 52.212-5: FAR 52.252-2, Clauses and provisions may be accessed in full text at http://farsite.hill.af.mil/; DFAR 252.212-7001 Contract Terms and Conditions Required to Implement Statutes or Executive Orders Applicable to Defense Acquisitions of Commercial Items. [in paragraph and (b) the following clause applies 252.225-7001;] Addendum to DFAR 252.212-7001 252.225-7002; All offers are due no later than 3:00 PM (Eastern Standard Time) 29 June 2004. Offers may be mailed to ESC/PKOP, ATTN: Kathleen M. Brock, 20 Schilling Circle, Bldg 1305, 3rd Floor, Hanscom AFB, MA 01731-2800, emailed to kathleen.brock@hanscom.af.mil, or faxed to (781) 377-0339 ATTN: Kathleen Brock. ADDITIONAL INFORMATION: Be advised that all interested parties must be registered in the Central Contractor Registration (CCR) Database in order to receive an award. If you are not registered you may request an application at (888) 227-2423 or through the CCR website at http://www.ccr.gov.
- Web Link
-
ESC Business Opportunities Web Page
(http://www.herbb.hanscom.af.mil)
- Place of Performance
- Address: N/A
- Zip Code: N/A
- Country: N/A
- Zip Code: N/A
- Record
- SN00610279-W 20040627/040625230630 (fbodaily.com)
- Source
-
FedBizOpps.gov Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |